服务热线 :

024-74565289

13941092358

销售部电话:024-74565289

                     024-74606896
技术部电话:024-74561558

COPYRIGHT © 2018 AIREP     ALL RIGHTS RESERVED    
辽ICP备12000599号-1     POWERED BY 网站建设:中企动力  沈阳

>
>
>
GZS系列双质体振动流化床干燥机
产品名称

GZS系列双质体振动流化床干燥机

处理量(吨/日)
降水幅度(%)
加热介质
热风温度(℃)
  该机实现了用一台该机代替几台普通振动床串联使用的情况,降低了设备投资及工程造价,同时先进的振动结构保证大型振动床宽度、长度方向上同步振动,解决了普通双电机振动床的偏流、沟流问题,避免了静止流化床的局部死床、壁面堆积、沟流、腾涌等问题。
产品描述

四、使用范围  /  Scope of use

 

一、概述 /  Overview

 
 

三、主要特点  /  Main feature

 

二、主要结构及工作原理  /  Main structure and working principle

 

  The drier is mainly composed of upper cavity, wind-box, base, fluidized bed plate, etc. The upper cavity and wind-box form upper body, and the base is lower body. The upper and lower bodies are connected by means of flat spring and helical spring. Vibration isolation is realized through rubber buffer between lower body and foundation. Box vibration exciter is mounted on the rear part of wind-box Box vibration exciter produces exciting horizontal force by motor through belt driving, so that the drier vibrates with certain frequency through effect of flat spring. The vertical force combined with the hot air passing through the nozzle board casts the material up, and mike it in the state of fluidization; at the same time the horizontal force transports the material forward at a certain speed, and the meterial will pass the weir and come out from the discarge funnel, and finish the drying. Wind cowls are fully distributed on fluidized bed plate, so as to prevent the product from falling into wind-box at the time of stopping, and horizontal air current is produced to ensure even fluidization of material. The charge level in the drier may be adjusted by overflow weir.

GZS系列双质体振动流化床干燥机  /  GZS series double mass vibration fluidized bed dryer

  干燥机主要由上腔、风箱、底座、流化床板等组成。上腔和风箱组成上质体,底座为下质体,上、下质体之间通过板弹簧和螺旋弹簧相连,下质体与基础间通过橡胶缓冲垫隔离振动。风箱后部装有箱式激振器箱式激振器由电机通过皮带传动,产生水平方向激振力,经板弹簧(共振簧)作用,使干燥机以一定的频率振动,垂直方向的分力与通过喷嘴板的热空气一起将喷嘴板上的物料抛起,使物料处于流化状态,而水平方向的分力使物料以一定速度向前输送,经溢流堰和出料斗排出,从而完成干燥作业。流化床板上布满风帽,防止产品在停车时掉入风箱内,并产生水平气流,确保物料流化均匀。干燥器内料位可由溢流堰调节。

该机具有以下特点:
1.流态化均匀稳定,无死床和吹穿、壁面堆积、沟流、腾涌现象,可获得均匀的干燥制品。
2.本机采用分离拖动方式,运转平稳,维修方便,噪音低,设备寿命长。
3.可调性好,料层厚度和物料在机内停留时间均可调节。
4.避免产品在停车时掉入风箱内,减少产品与干燥器底板接触和过热。
5.作业环境清洁,可连续作业。
6.高频率的振动使热风分布更均匀,提高了热风与湿物料的传热效率,节能效果好。

The machine has the following features:
1. Fluidization state is even and stable, there is no phenomenon of dead bed or blow breaking, wall sticking, channeling or over-flowing Evenly dried product may be gained
2. Separation driving mode is adopted for the machine, the operation is stable. the maintenance is convenient the noise is low and the service life of equipment is long
3. The adjustability is well, feed layer thickness and the staying time of material in the machine may be adjusted
4. Product is prevented from dropping into wind-box at the time of stopping, so as to reduce the contact between product and drier base plate and any overheating
5. The working envirenment is clean continuous working may be realized
6. Frequent vibration evens the distribution of the hot wind, promoting the heat trasfer rate between the hot wind and wet material. which increases the energy-saving effect

Our product has been widely applied in the fields of petrochemistry, fine chemicals, medcine, food, grain and cooking oil, feeding stuffs, salt marine products processing and superfine drying. It can lower the water content from 78% to 0.59

广泛适用于石油化工、精细化工、医药、食品、油、饲料、盐业、海产品加工及超细微干燥等领域,可以将初始含水量78%的产品干燥至0.5%。

  该机实现了用一台该机代替几台普通振动床串联使用的情况,降低了设备投资及工程造价,同时先进的振动结构保证大型振动床宽度、长度方向上同步振动,解决了普通双电机振动床的偏流、沟流问题,避免了静止流化床的局部死床、壁面堆积、沟流、腾涌等问题。

 

  This machine can take palce of several ordinary vibration beds connected in series, lowering the investment and the project cost Meanwhile, the advanced vibration structure makes sure that the large bed vibrates synchronously horizontally and vertically, solving the problems of drifting and channeling that are common when using double-pump vibration bed, which can also avoid the static fluidized bed' s defects, such as part dead bed, wall deposit, channeling overflowing, etc

未找到相应参数组,请于后台属性模板中添加
暂未实现,敬请期待
暂未实现,敬请期待
上一篇
下一篇